625755

Gys STARTIUM 680E Manual

8
Zoom out
Zoom in
Previous page
1/28
Next page
8
STARTIUM 330E / 480E / 680E / 980E
EN
Charging a battery not connected to the vehicle :
• Connect the red clamp to the positive battery terminal and then the black clamp to the negative terminal of the battery.
• After use, turn the switch to OFF, then disconnect the charger from the mains supply then disconnect the red clamp
and nally the black clamp.
USE IN CHARGING MODE (SEE INTERFACE)
Precautions before use
• Choose a well ventilated area
• Remove the caps on the battery (if any) and ensure the water level (electrolyte) is sufcient. Otherwise add deionized
water and carefully clean the battery terminals.
• Check that the battery capacity in ampere-hours and voltage in volts are compatible with the charger.
Testing the battery
Before charging the battery it is possible to test the battery. Connect the red clamp on 12 or 24V in accordance with the
battery voltage. The display will then show the voltage and the percentage of health. A 12V battery is at 100% of its
capacity if the voltage is greater than 12.8V. It will show 0% if the voltage is lower than 11.8V.For 24V, the battery is at
100% of its capacity if its voltage is higher than 25.6V. It is at 0% if the voltage is lower than 23.6V.
Charge
Once the charger is connected to the battery (see connection and disconnection), connect the red clamp on 12V or 24V,
select the charging level (key 13) according to the capacity (Ah)of the battery, select the battery type (key 12).
By default the appliance is congured on the charging level "3" and battery type: "Universal".
STARTIUM 330E STARTIUM 480E STARTIUM 680E STARTIUM 980E
12V 24V 12V 24V 12V 24V 12V 24V
Charge 1
20-75A
(5A)
20-75Ah
(5A)
20-75Ah
(5A)
20-75Ah
(5A)
20-75Ah
(5A)
20-75Ah
(5A)
20-75Ah
(5A)
20-75Ah
(5A)
Charge 2
40-150Ah
(10A)
40-150Ah
(10A)
60-225Ah
(15A)
40-150Ah
(10A)
60-225Ah
(15A)
60-225Ah
(15A)
85-300Ah
(20A)
60-225Ah
(15A)
Charge 3
60-225Ah
(15A)
60-225Ah
(15A)
130-450Ah
(30A)
60-225Ah
(15A)
130-450Ah
(30A)
100-375Ah
(25A)
170-600Ah
(40A)
130-450Ah
(30A)
Charge 4
100-375Ah
(25A)
85-300Ah
(20A)
170-600Ah
(40A) (boost)
130-450Ah
(30A) (boost)
200-675Ah
(45A) (boost)
150-525Ah
(35A) (boost)
210-750Ah
(50A) (boost)
150-525Ah
(35A) (boost)
The charge will ony start if the voltage of the battery is equal or greater than 1V.
The charging progress is stated in %. 0% = Battery recovery and 100% = Battery fully charged.
Automatic restart (Can be used only when charging)
Once the device is set correctly, press key 9 to start. Pressing key 9 for more than 5 seconds will enable an automatic
restart in the event of a power cut. In this case the voltage LEDs (V) and the percentage LEDs (%) will ash. If the
device has been started by pressing key 9 for less than 5 seconds, it will not restart automatically. In this case the LED's
will light one by one.
WARNING : To stop the charge in this mode press the key 9. A power cut won't stop the charge.
After use follow the recommended disconnection procedure.
UNIVERSAL function
In the event that it is not possible to accurately determine the battery type (liquid, gel, AGM, Start/Stop) then we
recommend that the UNIVERSAL settting is selected, this is also the default setting.
TIMER function
The TIMER key (14) enables the user to choose an adjustable charging time from 10 to 120 min with a 10 min step and
enables the charge to start under 1V and without battery.
Warning !
• This charge is 'manual''and will only stop at the end the congured time or by disconnecting the plug from the mains
or by pressing key 9. The display (2) indicates the charging time remaining in minutes and the battery voltage.
When the battery is charged, the electrolyte will 'boil'. When this occurs it is recommended to stop the charge to avoid
damaging the battery.
• If the clamps are disconnected or in short-circuit the charging cycle starts (risk of sparks) - This is a manual charge.
… 8 …


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Gys STARTIUM 680E at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Gys STARTIUM 680E in the language / languages: English, German, Dutch, French, Spanish as an attachment in your email.

The manual is 1,45 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info