644523

Zipper ZI-RPE60 Manual

21
Zoom out
Zoom in
Previous page
1/52
Next page
21
state of health and your physical
welfare.
Sources of danger of the working
area
Ensure that the walls of a trench are
steady and that they won’t tumble down
by the vibrations.
Ensure that there are no voltage-carrying
cables, gas lines or water pipes which can
be damaged during operation.
Be careful when you work near unpro-
tected holes or excavations. The opera-
tion of the machine happens on your own
responsibility and your discretion.
Burning hazard
Touching the muffler of the exhaust
may cause serious burnings when the
engine is hot.
Fire and explosion hazards
Petrol is flammable easily and at special
conditions explosive.
NEVER refill fuel during operation or when
the machine is hot.
Do not smoke and keep away flames and
sparks during refilling and at places
where fuel is stored.
Do not overfill the fuel tank and avoid
spilling petrol. When fuel has been spilled
you must clean that place before starting
the machine.
Ensure that the tank cap is fastened well
after refilling.
Chemical dangers
Never refill or operate a combustion en-
gine in a closed room without enough air
circulation.
Carbon monoxide from the combustion
engine can cause the death or can dam-
age your health by breathing in. That’s
why you’re only allowed to operate the
machine in good ventilated rooms and
outdoors.
Hazard of the sound
Excessive sound may cause hearing dam-
ages. For restricting the sound you have
to use hearing protection which is certi-
fied to health and safety directives.
Special protective clothing
Except of the directives in this manual for
wearing protective clothing you must
wear special safety clothing and safety
shoes when you work with bitumen mix-
tures.
Maintenance
Ensure that repairs on the machine will
only be done by qualified persons.
Make sure that the ignition is in the posi-
tion OFF and that the ignition cable is dis-
connected with the spark plug before you
remove protections, do maintenance
work or adjust something.
Don’t accelerate the controlled idle speed
of the engine over 3500 rpm. Each in-
creasing can cause injuries or damages
on the machine.
2.4 Operation instructions
IM PORT AN T
Do not operate the engine at maxi-
mum speed right from the start, as
the engine itself as well as the gear-
ing components need a running-in
time. The engine itself reaches its
maximum capacity after the first 10
hours of operation. Non-compliance
with this instruction reduces your
engine lifespan substantially.
2.4.1 Workings before starting up
Reading, understanding and obeying the
safety instructions.
Unpacking all the parts. Controlling the
plate compactor on dust and other dirt.
The machine is delivered remounted.
Swing out the handle and fix it with the re-
lated screws.
Control the screws and fasten them when
necessary before you start up the machine.
Controlling the oil level
ATTENTION!
The compactor has grease lubrication
on its disposal. For a fast and consis-
tent dispersion the manufacturer at-
taches some oil into the impregnator.
This oil escapes through a bleed
screw. Take care that the oil which
gets into the vibration plate won’t
dispense on your working ground.
ZIPPER does not assume liability for
dirty working areas!
… 21 …


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Zipper ZI-RPE60 at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Zipper ZI-RPE60 in the language / languages: English, German, French, Spanish as an attachment in your email.

The manual is 1,61 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info