Manual Stiga VILLA SILENT - 2010 (page 51 of 164) (All languages)

564032

Zoom out

Zoom in

1/164

ENGLISH

First service and intermediate service should be

carried out by an authorised workshop, but can

also be carried out by the user. The content of this

can be found in the service log and the actions are

described under “4” as well as below.

Servicing carried out at an authorised workshop

guarantees professional work using genuine spare

parts.

At each basic service and intermediate service

carried out at an authorised workshop, the service

log is stamped. A service log presenting these

services is a valuable document that improves the

machine’s second-hand value.

5.2 PREPARATION

All service and all maintenance must be carried out

on a stationary machine with the engine switched

off.

Prevent the machine from rolling by

always applying the parking brake.

Prevent unintentional starting of the

engine by disconnecting the spark plug

cable(s) from the spark plug(s) and

removing the ignition key.

5.3 TYRE PRESSURE

Adjust the air pressure in the tyres as follows:

Front: 0.4 bar (6 psi).

Rear: 1.2 bar (17 psi).

5.4 CHANGING ENGINE OIL

Change engine oil for the first time after 5 hours of

operation, and subsequently after every 50 hours

of operation or once a season.

Change the oil more often (after 25 hours of

operation or at least once a season) if the engine

has to operate under demanding conditions or if

the ambient temperature is high.

Use oil according to the table below.

Use oil without any additives.

Do not fill with too much oil. This can cause the

engine to overheat.

Change oil when the engine is warm.

The engine oil may be very hot if it is

drained off directly after the engine is

shut off. Therefore allow the engine to

cool a few minutes before draining the

oil.

1. Unscrew the oil drain plug (fig. 11).

2. Collect the oil in a collection vessel. Then take

the oil to a recycling station. Do not spill any oil

on the drive belts.

3. Screw in the oil drain plug.

4. Remove the dipstick and fill up with new oil.

Oil quantity:

12, 12 HST, 14 HST

: 1.2 l

Silent:

1.1 l

5. After filling up the oil, start the engine and idle

for 30 seconds.

6. Check to see if there is any oil leakage.

7. Stop the engine. Wait for 30 seconds and then

check the oil level in accordance with 4.2.

5.5 FUEL FILTER (8, 9:Q)

Replace the fuel filter every season. Check for fuel

leaks once the new filter has been installed.

5.6 BELT TRANSMISSIONS

After 5 hours of operation, check that all the belts

are intact and undamaged.

5.7 STEERING

The steering must be checked/adjusted after 5

hours of operation and thereafter every 25 hours of

operation.

5.7.1 Checks

Briefly turn the steering wheel back and forth.

There must be no mechanical clearance in the

steering.

5.7.2 Adjustment

Tension the steering cables by tightening up the

nut (fig. 12). Important! The screws in the ends of

the cable should be held firmly during adjustment

so that the cable is not twisted. Using an adjustable

wrench or similar, grasp the key handle on the

screws in the ends of the cable.

Adjust the steering cables until all play is removed.

Do not tension the steering cables too hard.

Otherwise the steering will be heavy and wear and

tear on the cables will increase.

5.8 BATTERY

Never overcharge the battery.

Overcharging can damage the battery.

Do not short-circuit the battery’s

terminals. Sparks occur which can

result in fire. Do not wear metal

jewellery which can come into contact

with the battery terminals.

In the event of damage to the battery

casing, cover, terminals or interference

to the strip covering the valves, the

battery should be replaced.

The battery is a valve-regulated battery with 12 V

nominal voltage. The battery fluid does not need to

and cannot be checked or topped up. The only

maintenance that is required is charging, for

example after extended storage.

Oil SAE 10W-30

Service class SJ or higher

Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

Forumrules

To achieve meaningful questions, we apply the following rules:

First, read the manual;
Check if your question has been asked previously;
Try to ask your question as clearly as possible;
Did you already try to solve the problem? Please mention this;
Is your problem solved by a visitor then let him/her know in this forum;
To give a response to a question or answer, do not use this form but click on the button 'reply to this question';
Your question will be posted here and emailed to our subscribers. Therefore, avoid filling in personal details.

new questions and answers
new manuals

You will receive an email to register for one or both of the options.

Get your user manual by e-mail

Enter your email address to receive the manual of Stiga VILLA SILENT - 2010 in the language / languages: All languages as an attachment in your email.

The manual is 4,45 mb in size.

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.

Info

Stiga VILLA SILENT - 2010 Manual

Product: