Manual Protool VCP 170 (page 9 of 27) (English, German, Dutch, Danish, French, Italian, Polish, Portuguese, Swedish, Spanish, Norwegian, Finnish)

490622

Zoom out

Zoom in

1/27

VCP 170 E VCP 171 E-L VCP 320 E VCP 321 E-L

............................................. 400-1200 W / 2400 W

............................................. 400-1200 W / 1100 W

............................................. 400-1200 W / 1800 W

............................................. 400-1200 W / 1200 W

........ 20.000 Pa .................20.000 Pa ............ 20.000 Pa .............. 20.000 Pa

.......... 3.000 l/min .............. 3.000 l/min ........... 3.000 l/min ............3.000 l/min

.......... 4.600 cm² ................ 3.600 cm² ............ 4.600 cm² ..............3.600 cm²

.............. 17 Liter ....................17 Liter ................32 Liter ................. 32 Liter

ø 27 mm x 3,5 m ............. ø 27mm x 3,5 m .........ø 27 mm x 3,5 m .......... ø 27 mm x 3,5 m

.................74 dB(A) .......................72 dB(A) ................. 74 dB(A) ................... 72 dB(A)

445x380x485 mm ........445x380x485 mm ... 550x380x485 mm .... 550x380x485 mm

............. 8,5 kg ......................8,5 kg ..................9,3 kg ................... 9,3 kg

............. 5,5 m ....................... 7,5 m ...................5,5 m .................... 7,5 m

.................I ............................. I ......................... I ..........................I

...........IP X4 .......................IP X4 ...................IP X4 ................... IP X4

value > 1 mg/m

) and for vacuuming dirt, dirt, sand,

chips and water.

This device is suitable for use on commercial premises,

e.g. hotels, schools, hospitals, factories, shops, ofﬁces

and leased businesses.

Wet ﬁlter 633583 does not meet the requirements of

dust class „L“ and should only be used to absorb

liquids.

If the appliance is used for uses other than that for

which it is designed, the user accepts all liability.

MAINS CONNECTION

Ensure that the voltage of the power supply matches

the information on the type plate of the power tool.

Tools with a rating of 230 V can also be connected to a

220 V/240 V supply.

Only connect the electric tool to the vacuum cleaner

when it is switched off.

Connect only to sockets with an earth contact.

EC-DECLARATION OF CONFORMITY

We declare under our sole responsibility that this

product is in conformity with the following standards or

standardized documents. EN 292-1, EN 292-2,

EN 60335-1, EN 60335-2-69, EN 55014-1, EN 55014-

2, EN 61000-3-2, EN 61000-3-3 in accordance with the

regulations 98/37/EG, 73/23/EWG, 89/336/EWG.

Manfred Kirchner

Manager Development

ENVIRONMENTAL PROTECTION

Only open the vacuum cleaner as described in these

instructions. Do not dismantled used appliances and

return them to the appropriate collection point for

recycling.

MAINTENANCE

Disconnect the vacuum cleaner from the mains supply

before you clean it.

If the suction power falls even after you have cleaned

the ﬁler, the ﬁlter must be replaced (see ﬁlter

replacement section in the picture section).

CAUTION! Clean the water level demarcation and

inspect it for damage regularly.

The manufacturer or a trained person must conduct a

technical inspection of the appliance at least once per

year, which, for example, includes an inspection of the

ﬁlter for signs of damage, checking that the appliance

is air-tight and testing the safety components (ﬁlter

element).

Accessories and spare parts can be ordered from a

service outlet, quoting the part number (see attached

list). The part numbers are shown in the tables in the

picture sections.

Use only Protool accessories and spare parts.

Components whose replacement is not described

should only be replaced at a service outlet.

TECHNICAL DATA

Power consumption / Socket connection

rating

EU (230 V, 50 Hz)) ...............................

CH, DK (230 V, 50 Hz) ..........................

GB (240 V, 50 Hz) ................................

AUS (240 V, 50 Hz) ...............................

Vacuum ...............................................

Delivery rate (without suction hose) ........

Filter surface area ................................

Tank capacity .......................................

Suction hose ........................................

Noise level to EN 60704-1 .....................

Dimensions ..........................................

Weight ................................................

Length of mains lead .............................

Protection class ....................................

Protection type .....................................

The noise level when working can exceed

85 dB (A). Wear ear protectors!

SPECIAL SAFETY INFORMATION

This machine can only be operated safely when the

operating instructions and the pamphlet containing the

safety instructions have been completely read and

strictly adhered to.

Always inspect cable and plug before using machine.

Only have damage repaired by a qualiﬁed professional.

Make sure machine is switched off before inserting plug

in socket.

The plug socket on the appliance may be used only for

the purposes deﬁned in the usage instructions.

If the mains connection cable is damaged the machine

must not be used.

Make sure that the mains connection cable is not

damaged, squashed, bent, or damaged by being run

over or in any other way.

Extension cables to the mains must at least be

protected from water spray and contain an earth lead.

The appliance must be connected to a cable that is

protected by a circuit breaker or a fusible insert with

the following minimum current strength.

CH, DK, AUS: 10 A

GB: 13 A

EU: 16 A

The appliance may only be used in a room that has

adequate ventilation (comply with national safety at

work regulations).

Comply with the applicable safety regulations of the

material manufacturer when vacuuming.

Do not vacuum any inﬂammable or explosive ﬂuids (for

example petrol, alcohol, thinners, solvents, etc.) –

Risk of explosion.

Do not suck in any combustible or explosive dusts (e.g.

magnesium, aluminium etc.) - Danger of explosion!

Do not vacuum any sparks or hot parts (for example

metal chips, ash, etc.) whose temperature exceeds

60°C – Risk of explosion and ﬁre.

Do not vacuum any aggressive ﬂuids or solids (acids,

lyes, solvents, etc.).

You are not allowed to use the appliance in the vicinity

of inﬂammable gases or substances.

Do not put appliances or accessories into operation, if:

the appliance has recognizable damage (cracks/

breaks), the mains connection lead is defective or

shows signs of cracking or aging, there is a suspected

non-visible defect (after having been dropped).

CAUTION! If any foam or water egresses, switch off

immediately. Empty the container and, if need be, the

pleated ﬁlter.

Acids, acetone and solvents can corrode the appliance

components.

In the event of misuse, improper operation or

unprofessional repair work no liability shall be assumed

by us for any damage incurred.

Not suitable for sweeping up liquids which form a large

foam.

CAUTION! This device must not be used or stored

outdoors in wet conditions.

The power supply cord may only be replaced with one

of the following type:

VCP 170 E, VCP 320 E: H05 VV-F

VCP 171 E-L, VCP 321 E-L: H05 RR-F.

CAUTION! The device contains noxious dust. Emptying

and maintenance procedures, including the removal of

dust collectors, may only be carried out by trained

personnel wearing appropriate protective gear. Do not

operate without complete ﬁltration system.

Before using the device, users must be given

information on the use of the device and on how to

handle and dispose of the hazardous substances for

which the device is intended to be used.

When emptying or cleaning the device or changing the

ﬁlter, personnel must be wearing suitable equipment to

protect them from the harmful substances. Before this

work is undertaken the device must be

decontaminated. The rooms in which these procedures

are carried out must have a local exhaust ventilation

system and the area must be cleaned afterwards in

accordance with regulations.

When carrying out maintenance and repair work it is

necessary to dispose of any contaminated objects

which cannot be adequately cleaned. Such objects

must be placed in impermeable bags in compliance

with the relevant regulations for the disposal of such

refuse.

IMPORTANT. Do not use without the complete

ﬁltration system.

INTENDED USE

VCP 170 E, VCP 320 E: These vacuum cleaners are

designed for vacuuming non-hazardous dust, dirt,

sand, chips and water.

VCP 171 E-L, VCP 321 E-L: These vacuum cleaners

are designed for vacuuming hazardous dust in dust

safety class L (maximum workplace concentration

ENGLISHENGLISH

Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

Forumrules

To achieve meaningful questions, we apply the following rules:

First, read the manual;
Check if your question has been asked previously;
Try to ask your question as clearly as possible;
Did you already try to solve the problem? Please mention this;
Is your problem solved by a visitor then let him/her know in this forum;
To give a response to a question or answer, do not use this form but click on the button 'reply to this question';
Your question will be posted here and emailed to our subscribers. Therefore, avoid filling in personal details.

new questions and answers
new manuals

You will receive an email to register for one or both of the options.

Get your user manual by e-mail

Enter your email address to receive the manual of Protool VCP 170 in the language / languages: English, German, Dutch, Danish, French, Italian, Polish, Portuguese, Swedish, Spanish, Norwegian, Finnish as an attachment in your email.

The manual is 1,84 mb in size.

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.

Info

Protool VCP 170 Manual

Product: