514481
138
Zoom out
Zoom in
Previous page
1/172
Next page
5-26
LENKER
HAUPTBREMSZYLINDER
DEMONTIEREN
1. Demontieren:
Hauptbremszylinder-Halterung
"1"
Hauptbremszylinder "2"
Den Hauptbremszylinder nicht
am Bremsschlauch hangen las-
sen.
Den Bremsflussigkeits-Vorrats-
behalter waagerecht halten,
damit keine Luft in das System
eindringt.
GRIFF DEMONTIEREN
1. Demontieren:
Lenkergriff "1"
Druckluft zwischen dem Lenker bzw.
der Führung und dem Lenkergriff bla-
sen. Anschließend den gelösten Griff
abnehmen.
LENKER KONTROLLIEREN
1. Kontrollieren:
Lenker "1"
Verbogen/rissig/beschädigt
Erneuern.
Ein verbogener Lenker darf unter
keinen Umständen gerichtet
werden, weil dadurch seine Stabil-
ität verloren geht.
GASDREHGRIFF
ZUSAMMENBAUEN
1. Demontieren:
Lenkergriff rechts "1"
Klebstoff auf die Führung "2"
auftragen.
•Vor dem Auftragen von Klebstoff
muss die Führungs-Oberfläche "a"
mit Verdünner von Öl- und Fett-
spuren befreit werden.
•Die Ausgleichsmarkierung "b" an
dem Griff (rechts) mit dem Schlitz
"c" in der Rohrführung ausrichten.
2. Montieren:
Griffkappe (oben) "1"
Griffkappe (unten) "2"
Schraube (Griffkappe) "3"
Die Schrauben (Griffkappe) vorläufig
festziehen.
LENKERSTUMMEL MONTIEREN
1. Montieren:
Untere Lenker-Halterung "1"
Beilagscheibe "2"
Mutter (Untere Lenker-Halterung)
"3"
Die untere Lenker-Halterung so
montieren, dass der größere Ab-
stand "a" zur Achse der Lenkerhal-
terungs-Schraube nach vorn
gerichtet ist.
Das Gewinde der unteren Lenker-
halterungen mit Lithiumseifenfett
bestreichen.
Durch umgekehrten Einbau der un-
teren Lenker-Halterung kann die
Einbaulage des Lenkers nach vorn
oder hinten verändert werden.
Die Muttern noch nicht festziehen.
2. Montieren:
Lenker "1"
obere Lenker-Halterung "2"
Schraube (obere Lenker-Halter-
ung) "3"
Die obere Lenker-Halterung muss
so montiert werden, dass die
Körnermarkierung "a" nach vorn
gerichtet ist.
Den Lenker so montieren, dass die
Markierungen "b" an beiden Seiten
fluchten.
Den Lenker so montieren, dass der
Vorsprung "c" der oberen Lenker-
Halterung auf die Lenker-Markier-
ung ausgerichtet ist, wie darg-
estellt.
Zuerst die Schrauben an der
Vorderseite festziehen, danach die
Schrauben an der Hinterseite
vorschriftsmäßig festziehen.
Schraube (obere Lenker-
Halterung):
28 Nm (2.8 m•kg, 20
ft•lb)
138


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Yamaha YZ125 at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Yamaha YZ125 in the language / languages: German as an attachment in your email.

The manual is 8,43 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of Yamaha YZ125

Yamaha YZ125 User Manual - English - 168 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info