802483

Webasto LGW 300 Manual

2
Zoom out
Zoom in
Previous page
1/7
Next page
General information!
Dear SPHEROS user,
We assume that the operation and function of your new heater will have been explained
to you properly and to your complete satisfaction by the installing workshop/service
outlet. This owner's handbook is designed to give you a brief summary of how to use the
GBW heaters.
Maintenance and safety instructions
For the heater exists a type approval according to ECE Regulations R122 (Heater) and
R10 (EMC).
The heaters must be installed as described in the attached installation instructions and
must be registered on the vehicle registration document. If applicable, the approval
confirmation or the general operating licence must be carried in the vehicle.
The year in which the heater is used for the first time must be permanently marked on
the heater's model plate by removing the inapplicable year numbers.
Switch off the auxiliary heating system before refuelling.
The heater must not be operated:
The heater must:
Liability:
G
G
The heater must not:
The gas controller must:
D
Brand-, Explosions-
und
Erstickungsgefahr
!
nbe operated using the gas type shown on the model plate
(for the NGW 300 with a minimum methane content of 95%)
and the rated voltage shown on the model plate. If the
methane content is lower than this, the heater's gas nozzle is
to be adjusted by SPHEROS trained personnel. The oil content
of the gas must not exceed 70 ppm.
nbe taken out of operation by removing the fuse if smoke
develops, if unusual burning noises are heard or if there is a
smell of fuel. The heater must not be restarted until the unit
has been checked by personnel duly trained by SPHEROS.
nbe run for 10 minutes at least once per months when the
engine is cold and with the blower at its lowest setting. At
the latest at the start of the cold weather the heater must be
inspected by an expert. For this purpose the CO value must
be checked and adjusted. In addition it must be checked
whether disconnecting the control valve results in the
immediately extinguishing of the flame (burning noise). If
not, the controller must be replaced.
nNon-compliance with the installation instructions and the
warnings contained therein will lead to the exclusion of all
liability by SPHEROS. The same also applies if repairs are not
undertaken by professionals or without using genuine spare
parts. This invalidates the type approval for the heater and
its homologation / ECE type permit.
nLiability claims can only be made if the claimant can verify
compliance with all the servicing and safety instructions.
nbe exposed to temperatures of more than 120 °C (storage
temperature), otherwise the electronics may suffer
permanent damage.
nbe operated without at least 20% brandname anti-freeze in
the water of the heating circuit.
nbe replaced after four years for safety reasons
(manufacturer's directive). If you fail to do this it may leak
and gas may escape
nbe drained of oil through the oil drain screw every three
months (by SPHEROS trained personnel).
Operating and
maintenance instructions
GBW 300
NGW 300 / LGW 300
nat filling stations and other refueling points.
nif the heater or its exhaust outlet is in locations where
inflammable vapors or dust may form (e.g. close to fuel, coal,
wood dust or cereal storage facilities).
nif the heater or its exhaust outlet is located close to
inflammable materials for example dry grass and leaves,
cartons, paper etc.
nin enclosed areas (e.g. garages, hall without a suck off
facility), not even if the digital timer or Tele Start is used.
nIf the exhaust outlet of the heater is partial or fully
obstructed (e.g. by soil or snow, as it may occur while move
the vehicle backwards).
nNGW 300 at temperatures of less than -25°C and the LGW
300 at temperatures of less than -20°C.
nAt altitudes of over 1500 m.
2


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Webasto LGW 300 at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Webasto LGW 300 in the language / languages: English as an attachment in your email.

The manual is 0.65 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of Webasto LGW 300

Webasto LGW 300 User Manual - German - 7 pages

Webasto LGW 300 User Manual - French - 7 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info