802146
5
Zoom out
Zoom in
Previous page
1/9
Next page
Fuel | 4
9032569B OI Air Top 2000 STC 5 / 9
3.2 Setting up a vehicle heating system
NOTE
Depending on the type of vehicle, the air-conditioning
system can perform these settings automatically or
partly autonomously. Ask your specialist dealer to ex-
plain the optimum settings.
1. Before switching on the heater (with the ignition on), set
the vehicle heating system to “warm”.
2. Set the vehicle fan to the lowest setting (lower power con-
sumption).
3.3 Switch the heater on and off
The heater is switched on and off by different switch signals.
Depending on the system equipment, the switch signals are
produced by a switch, control element or a climate control sys-
tem.
DANGER
Danger of explosion and suffocation
For ADR vehicles: The heater must only be switched on
manually via a switch. The heater must not be switched
on automatically via a programmable switch.
DANGER
Overheating possible
An emergency off switch may only be actuated in the
event of danger since the heater will be switched off
without after-running period.
NOTE
Always switch off the heater via the control ele-
ment
After switching off via the control element, the heater
switches to a short controlled run-on phase. Switching
off incorrectly, without after-run, can cause damage to
the heater.
3.4 Using the heater in hazardous
material vehicles (ADR)
It is not possible to set a preselection time in hazardous material
vehicles (ADR). The SmartControl (if present) shows how much
heater operation time is left (remaining operation time).
NOTE
An ADR after-running period is applied in the fol-
lowing cases:
- the generator signal (D+, light machine) is discontin-
ued.
- the pumping device (auxiliary drive) belonging to the
vehicle is put into operation.
After the end of the ADR after-running period, the
heater is in ADR locking mode.
NOTE
Release ADR lock:
uPut the pumping device belonging to the vehicle out
of operation.
uRestart the heater by switching it off and on again
using the control element.
3.5 Switching the heater on after
automatic switch-off
NOTE
Possible loss of heating function
Following an automatic switch-off, the heater may
need to be manually switched back on. The heater can
be restarted by switching it off and on again using the
control element.
4 Fuel
The heater is connected to the fuel tank of the vehicle or to a
separate fuel tank.
Suitable fuels:
lAir Top 2000 STC D: Diesel DIN EN 590; biodiesel DIN EN
14214 and HVO DIN EN 15940
lAir Top 2000 STC B: Petrol DIN EN 228
4.1 Converting from operation with
summer diesel to winter diesel
üThe tank is filled up with winter diesel (cold-resistant fuel).
However, the fuel system for the heater may still contain
residues of summer diesel.
uSwitch on the heater for approx. 15 minutes (the fuel sys-
tem is completely filled with cold-resistant fuel).
5 Combustion air
DANGER
Danger of fire
Flammable materials or liquids in the hot air flow.
uKeep the hot air flow free
6 Exhaust
WARNING
Blockages
Check combustion air and exhaust system for block-
ages.
A blocked exhaust system or combustion air system can
cause unsafe status of the heater!
7 Cleaning
NOTE
Do not clean the Air Top 2000 STC with a high-pressure
cleaner.
Carefully clean the heater using water and a cleaning agent suit-
able for cleaning vehicles.
8 Malfunctions
WARNING
Check combustion air and exhaust system for
blockages.
A blocked exhaust system or combustion air system can
cause unsafe status of the heater!
In the event of a malfunction, the control element can indicate
a malfunction.
A malfunction is indicated by means of a flash code or on the
control element display:
lOn control elements with display, the fault codes F01 to
F15 are output via the display. The fault codes F16 to F19
are shown with “- -”.
5


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Webasto Air Top 2000 STC at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Webasto Air Top 2000 STC in the language / languages: English as an attachment in your email.

The manual is 11.89 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of Webasto Air Top 2000 STC

Webasto Air Top 2000 STC User Manual - German - 9 pages

Webasto Air Top 2000 STC User Manual - Dutch - 10 pages

Webasto Air Top 2000 STC User Manual - French - 10 pages

Webasto Air Top 2000 STC User Manual - Italian - 10 pages

Webasto Air Top 2000 STC User Manual - Spanish - 10 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info