667328

Viking MT 4097SX Manual

56
Zoom out
Zoom in
Previous page
1/332
Next page
0478 192 9803 B - EN
54
Fault:
Starter turns, engine does not start.
Possible cause:
– Throttle lever set to MIN position.
– Choke position (throttle lever) is not
selected.
– Choke knob not operated
(MT 4112 SZ).
– No fuel in tank.
– Fuel cock closed.
– Insufficient flow of fuel.
– Spark plug dirty or damaged.
– Incorrect electrode gap.
– Spark plug socket detached from the
spark plug.
– Engine is flooded due to several
starting attempts.
– Clogged air filter.
– Battery almost discharged.
Remedy:
– Set the throttle lever to the MAX
position.
– Set throttle lever to the choke
position. (Ö 8.2)
– Operate choke knob (MT 4112 SZ).
(Ö 8.4)
– Refill fuel tank.
– Open fuel cock. (Ö 13.12)
– Check fuel filter. (@)
– Clean or replace spark plug. (@)
– Adjust electrode gap. (#)
– Connect spark plug socket; check
connection between ignition lead and
socket. (#)
– Remove spark plug and dry; set throttle
lever to MIN position and start several
times with spark plug removed; screw in
spark plug and connect spark plug
socket. (@)
– Clean the air filter. (@)
– Check charge state of the battery and
charge battery if necessary. (Ö 13.16)
Fault:
Starter not functioning.
Possible cause:
– The safety devices are blocking the
starter.
– Battery not or incorrectly connected.
– Battery completely discharged or not
sufficiently charged.
– Main fuse (150 A) defective.
– Faulty earth connection to engine or
chassis.
– Starter defective.
Remedy:
– Check all the safety devices. (Ö 10.)
– Check battery connections. (Ö 13.15)
– Charge the battery. (Ö 13.16)
– Replace the main fuse. (#)
– Check the connection cables at the
battery and at the chassis. (#)
– Repair the starter. (#)
Fault:
Starting problems or deteriorating engine
power.
Possible cause:
– Water in fuel tank and carburettor;
carburettor is blocked.
– Contaminated fuel tank.
– The air filter is dirty.
– Dirty spark plug.
– Mowing grass which is too long or too
wet.
Remedy:
– Empty fuel tank, clean fuel tank, fuel
line and carburettor. (#)
– Clean fuel tank. (#)
– Clean/replace air filter. (@)
– Clean spark plug. (@)
– Adapt cutting level and driving speed to
the mowing conditions.
Fault:
Engine overheating.
Possible cause:
– Dirty cooling ribs.
– Engine oil level too low.
– V-belt worn.
Remedy:
– Clean cooling ribs. (@)
– Check the engine oil level and top up
the engine oil if necessary. (Ö 13.9)
– Replace the V-belt. (#)
Fault:
Machine does not drive.
Possible cause:
– Gearbox disengaged.
– V-belt (gearbox) detached.
– V-belt (gearbox) worn or defective.
– Missing feather key between rear axle
and rear wheels.
Remedy:
– Engage the gearbox (freewheel lever).
(Ö 8.13)
– Fit V-belt (gearbox). (#)
– Replace V-belt (gearbox). (#)
– Install feather key. (Ö 13.8)
21. Troubleshooting
# If necessary, contact a specialist
dealer; VIKING recommends VIKING
specialist dealers.
@ See engine instruction manual.
… 56 …


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Viking MT 4097SX at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Viking MT 4097SX in the language / languages: English, Danish, Polish, Swedish, Norwegian, Finnish as an attachment in your email.

The manual is 26,4 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of Viking MT 4097SX

Viking MT 4097SX User Manual - German, Dutch, French, Italian, Portuguese, Spanish - 350 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info