802498

Valeo Thermo S Manual

2
Zoom out
Zoom in
Previous page
1/8
Next page
General Information
Dear Spheros Customer,
We assume that the operation and function of your new heater will have been explained
to you properly and to your complete satisfaction by the installing workshop / service
outlet. This owner's handbook is designed to give you a brief summary of how to use the
Thermo S 160/230/300/350/400 heaters.
The heater operation is unlimited without a change of the CO2 adjustment up to an
altitude of 1500 m above MSL and up to 2000 m above MSL if that is a short stay in such
conditions (pass crossing, break).
In case of a permanent heater operation above 1500m the CO2 setting should be
readjusted, due to a change of the exhaust gas values depending on environmental
conditions.
Service and safety instructions
For the heater exist type approvals according to ECE Regulations R122 (Heater) and
R10 (EMC).
The heaters must be installed as described in the attached installation instructions. The
installation must be checked pursuant to the statutory regulations governing
installation work. Further details are given in the installation instructions.
The year in which the heater is used for the first time must be permanently marked on
the heater's model plate by removing the inapplicable year numbers.
Ensure that the existing shut-off devices in the fuel return line are open prior to starting
the heater.
When the coolant used in the vehicle's engine is renewed, after bleeding the vehicle's
cooling system, pay attention to bleeding the heater carefully. Top up the coolant as
described in the instructions supplied by the vehicle manufacturer.
Check the openings of the combustion air intake and exhaust outlet and clean them if
necessary.
Switch off the auxiliary heating system before refueling.
The heater must not be operated:
Risk of fire,
explosion
and asphyxiation
!
The heater must:
G
nbe operated using the fuel type shown on the model plate
and the rated voltage shown on the model plate (for further
fuel types and operating limits, refer to the installation
instructions).
nbe shut down by removing the fuse in the event of extensive
smoke development, unusual combustion noises or fuel
odors.
The heater must not be used again until personnel trained
by Spheros have examined it.
nbe operated at least once per month for 10 minutes when
the engine is cold and with the blower at its lowest setting.
At the latest when the cold weather season starts the heater
must be inspected by an expert.
Liability claims:
nFailure to follow the installation instructions and the notes
contained therein will lead to all liability being refused by
Spheros. The same applies if repairs are carried out
incorrectly or with the use of parts other than genuine spare
parts. This will lead to the invalidation of the type approval
for the heater and therefore of its general operating license /
ECE type licence.
nLiability claims can only be made if the claimant has
verifiably considered all the servicing and safety instructions.
The heater must not:
Dnbe exposed to temperatures exceeding 110°C (storage
temperature). Exceeding this temperature may result in
permanent damages.
nbe operated without at least 20% of a brand name anti-
freeze in the heating system water.
nat filling stations and other refueling points.
nif the heater or its exhaust outlet is in locations where
inflammable vapors or dust may form (e.g. close to fuel, coal,
wood dust or cereal storage facilities).
nif the heater or its exhaust outlet is located close to
inflammable materials for example dry grass and leaves,
cartons, paper etc.
nin enclosed areas (e.g. garages, hall without a suck off
facility), not even if the digital timer or Tele Start is used.
nIf the exhaust outlet of the heater is partial or fully
obstructed (e.g. by soil or snow, as it may occur while move
the vehicle backwards).
Thermo S
160/230/300/350/400
Operating and
service instructions
2


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Valeo Thermo S at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Valeo Thermo S in the language / languages: English as an attachment in your email.

The manual is 0.85 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of Valeo Thermo S

Valeo Thermo S User Manual - German - 8 pages

Valeo Thermo S User Manual - French - 8 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info