802492

Valeo Thermo E plus Manual

7
Zoom out
Zoom in
Previous page
1/12
Next page
General Information
Dear Valeo Customer,
We assume that the operation and function of your new heater will have been explained to
you properly and to your complete satisfaction by the installing workshop / service outlet.
This owner's handbook is designed to give you a brief summary of how to use the Thermo
E+ 120/200/320 heaters.
The heaters are set at the factory and can be used without any changes in the CO setting for
2
unrestricted heating operation up to 1,000 m above sea level, up to 2,000 m above sea
level (Thermo E + 120: up to 1,500 m) even for short stays (pass crossings, breaks).
An operating voltage of at least 13 V / 26 V must be ensured for the parking heating mode
at these altitudes.
With continuous use over 1,500 m (Thermo E + 120: 1,000 m), the CO setting must be
2
readjusted because the lower air density leads to a negative change in the exhaust gas
values.
The CO value is to be readjusted in accordance with the specified technical data if this is
2
necessary for applications on the intake or exhaust side, or the predominantly intended
operating altitude of the heater.
Service and safety instructions
For the heater exist type approvals according to ECE Regulations R122 (Heater) and R10
(EMC).
The heaters must be installed as described in the appropriate installation instructions. The
installation must be checked pursuant to the statutory regulations governing installation
work. Further details are given in the installation instructions.
The year in which the heater is used for the first time must be permanently marked on the
heater's model plate by removing the inapplicable year numbers.
Ensure that the existing shut-off devices in the fuel lines are open and the fuel system,
including the fuel filter, is carefully pre-filled and bled prior to starting the heater.
When the coolant used in the vehicle's engine is renewed, after bleeding the vehicle's
cooling system, pay attention to bleeding the heater carefully. Top up the coolant as
described in the instructions supplied by the vehicle manufacturer.
Check the openings of the combustion air intake and exhaust outlet periodically and clean
them if necessary.
Operating and
service instructions
The heater must not be operated:
The heater must:
The heater must not:
The heater must:
nwith a diesel fuel approved by Valeo in accordance with DIN EN 590 (see Fuels under
Service / Technical Updates on the Valeo website for more information) and the rated
voltage shown on the model plate.
nbe operated at least once per month for 10 minutes when the engine is cold. At the
latest when the cold weather season starts the heater must be inspected by an expert.
nbe exposed to temperatures exceeding 90°C (storage temperature). Exceeding this
temperature may result in permanent damages.
nbe operated without at least 30 % of a brand name anti-freeze in the heating system
water. An up-to-date list of anti-freeze approved by Valeo can be found on the Valeo
website.
nbe shut down and the fuse shall be removed in the event of extensive smoke
development, unusual combustion noises or fuel odors. The heater must not be used
again until personnel trained by Valeo have examined it.
nat filling stations and other refueling points.
nif the heater or its exhaust outlet is in locations where inflammable vapors or dust may
form (e.g. close to fuel, plastic, coal, wood dust or cereal storage facilities).
nif the heater or its exhaust outlet is located close to inflammable materials for example
dry grass and leaves, cartons, paper etc.
nin enclosed areas (e.g. garages, hall without a suck off facility), not even if the pre-
selection timer or a remote control is used.
nif the exhaust outlet of the heater is partial or fully obstructed (e.g. by soil or snow, as
it may occur while move the vehicle backwards).
WARNING! Risk of fire, explosion, poisoning
and asphyxiation!
ATTENTION:
Thermo E+
120/200/320
… 7 …


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Valeo Thermo E plus at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Valeo Thermo E plus in the language / languages: English, German as an attachment in your email.

The manual is 1.19 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info