484677

Truma Mover Euro Mover M1 Manual

21
Zoom out
Zoom in
Previous page
1/58
Next page
19
Installation instructions
Please fold out the page with diagrams!
Read the installation instructions prior to starting work and
follow them carefully!
Intended use
The Euro Mover has been built for use with single-axis
caravans with a gross weight of up to 1700 kg.
Installation using the standard installation kit is only possible
on caravans/trailers within the following dimensions.
all dimensions in mm
* With fully loaded vehicle
A distinction is made between L-profiled and U-profiled
chassis as shown in the illustration.
Measuring the chassis height
Chassis height (Y), measured at point (X)
X = 140 mm
Determining the installation type
1. Standard installation
Standard installation is used with an L-profile chassis and a
frame height (Y) of approx. 185 mm. No special accessories
are required.
2. Installation on a chassis with U-profile
Standard installation is used with a U-profile chassis and a
frame height (Y) of approx. 185 mm. A U-profile chassis kit
is needed to compensate for the profile edge.
3. Installation on a chassis with L-profile and frame
height of between 140 and 185 mm
With a chassis with a frame height (Y) of 140 mm to 185 mm,
1, 2 or 3 spacer plate sets and the U-bolt extension kit are
needed to compensate for the height.
4. Installation on a chassis with U-profile and frame
height of between 140 and 185 mm
The U-profile chassis kit, 1, 2 or 3 spacer plate sets and
the U-bolt extension kit are required to compensate for the
U-profile chassis edge and the height.
min.
195*
max. 1760
max. 2400
min. 50
min. 30
max. 48
min. 185
min. 2.8
max. 3.5
min. 240
Caravan Floor
5. Installation on a chassis with L- and U-profiles with
frame height of less than 140 mm
On a chassis with a frame height (Y) of less than 140 mm a
low chassis kit must be fitted to compensate the height.
In Germany, the low chassis kit installation must be
accepted by a vehicle expert.
6. The AL-KO Vario III / AV installation kit must be used
with the AL-KO Vario III / AV chassis with a frame thickness of
less than 2.8 mm.
Special accessory installation
1. U-bolt extension kit
(for chassis with L-profile, frame height
from 140 to 185 mm)
U-bolts, nuts and washers,
Part. no. 60010-00100.
1.1. Spacer plate kit
(two 15 mm spacer plates)
for height compensation
max. 45 mm (3 plates) at each side
(e.g. installed behind axle)
Part. no. 60010-65000.
2. Low chassis kit
for height compensation for
caravan/trailer with frame height of
less than 140 mm,
Part. no. 60010-09400.
In Germany, this installation
kit must be accepted by a
vehicle expert.
3. U-profile chassis kit
(for chassis with U-profile,
frame height approx. 185 mm)
U-bolt with clamping plates and
self-locking nuts, stoppers,
Part. no. 60010-09200.
4. AL-KO Vario III / AV
Installation kit
for caravans with
AL-KO Vario III / AV Chassis
(frame thickness less than
2.8 mm) mandatory,
Part. no. 60010-21500.
5. Cross actuation device
(for swivelling both drive units
against the wheels from one
side and releasing them again)
connecting tube, middle tube,
nuts, bolts, grub screws,
Part. no. 60010-18500.
The Euro Mover is not approved for installation on
caravans/trailers with any other chassis! Any drilling
(exception: when using flat frame kit) or welding to the chassis
is not allowed. Under no circumstances remove any suspen-
sion components from the chassis.
100
60
15
Ø 11
30
60
23
… 21 …


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Truma Mover Euro Mover M1 at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Truma Mover Euro Mover M1 in the language / languages: English, German, Dutch, Danish, French, Italian, Spanish as an attachment in your email.

The manual is 3,61 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info