673282
14
Zoom out
Zoom in
Previous page
1/23
Next page
14
§INSPECTION AND REPLENISHMENT OF ENGINE OIL§
Inspection:
Turn the main switch to the ON” position, if the oil warning
light comes on continuously, this indicates the engine oil
level is too low, add oil as required.
Check oil tank and oil lines for leakage.
Replenishment:
1. Using the main stand to support the vehicle on a level ground, lift up the seat, and remove the oil tank
cover.
2. Turn the oil tank cap to the left to remove. Add oil until reaches to the standard level.
3. Screw in the oil tank cap until properly tightened, then reinstall the tank cover and lower the seat and
press it down until locked.
§TRANSMISSION OIL INSPECTION AND CHANGE§
INSPECTION:
Use the main stand to support the motorcycle on a level ground, after the engine stops, wait for 3~5
minutes. Remove the transmission oil infusion bolt, put a measuring glass under the drain bolt, and
remove the drain bolt. Let the oil flows into measuring glass and check for decreased or not. (at
disassembly:110c.c/at change:90~100c.c.).
OIL REPLACEMENT:
Stop the engine and use the main stand to support your motorcycle on a
lever ground. Remove the infusion bolt and drain bolt, drain out the oil.
Install the drain bolt and tighten it. Fill new transmission oil (90~100c.c.),
and install the infusion bolt and tighten it. (Make sure that bolts are
tightened and check that there’s no leakage.)
Recommend Oil: Genuine SYM HYPOLD GEAR OIL (SAE 85W-140).
Use SAE85-90 when outside pemperature is below 0
To remind you:
To continue ride the scooter under low oil level condition
will result in an engine seizure due to lack of lubrication of
engine parts. It is therefore very important to bring your
scooter to your dealer for an oil replenishment immediately
whenever the warning light comes on continuously.
Use only 2-cycle engine oil meeting Japanese Automobile
Standard Organization FC specifications. Otherwise, this
company will not assume any responsibility for damages
resulted from using substandard engine oil.
Recommended oil: SYM EXTRA 2X oil.
Add oil note:
Use only 2-cycle engine oil meeting Japanese Automobile Standard Organization FC specifications.
SANYANG will not assume responsibility for damages caused from using substandard engine oil.
When adding oil, do not let foreign matter, such as dust, dirt, etc. to enter into the oil system. Do
not use different brands of mixed oil.
Do not add oil above the standard level. Clean spilled oil around the oil cap.
Be sure to properly tighten the oil cap after adding oil and before riding the scooter.
14


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Sym Jet 4 - 50R at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Sym Jet 4 - 50R in the language / languages: English as an attachment in your email.

The manual is 1,88 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info