Manual Kymco Super 8 - 150 (page 16 of 56) (English)

598326

Zoom out

Zoom in

1/56

Break-in recommendations

The first 600 miles (1,000 km) of riding are the most important

in the life of your scooter. Proper break-in operation during

this time will help ensure maximum life and performance from

your new scooter. Proper break-in operation allows the ma-

chined surfaces to polish each other and mate smoothly.

Your scooter’s reliability and performance depend on special

care and restraint exercised during the break-in period. It is

especially important that you avoid operating the engine in a

manner which could expose the engine parts to excessive heat.

The following guidelines should be followed during the break-

in period:

Maximum throttle operation:

Initial 300 miles (600 km): ...............Less than 1/2 throttle

Up to 600 miles (1,000 km): ............Less than 3/4 throttle

Vary the engine speed:

The engine speed should be varied and not held at a constant

rate for long periods of time. This allows the parts to be "loaded"

with pressure, and then unloaded, allowing the parts to cool.

This aids in the mating process of the engine and transmis-

sion components. It is essential that some stress be placed

on these components during break-in to ensure this mating

process. Do not, however, apply excessive load on the scooter's

drive line.

Avoid constant low speed:

Operating the engine at constant low speed (light load) can

cause parts to glaze and not seat in properly. Allow the engine

to accelerate freely through the gears, without exceeding the

recommended throttle openings.

Avoid using full throttle for the first 300 miles (500 km).

The initial service:

Observe your first and most critical service. The 200 mile (300

km) initial service is the most important service your scooter

will receive. During the break-in period all of the engine com-

ponents will have worn in and all of the other parts will have

seated in, so adjustments will be required. All fasteners will be

tightened, and the contaminated engine oil will be replaced.

NOTE: Completion of the 200 mile (300 km) initial service

will ensure optimum service life and performance from

your scooter. Do not delay in having this service performed

once your scooter reaches this mileage.

SECTION 3 -

OPERATION

Hello . I buy one oil filter for my kymco super 8 ..150cc .but the have no filter i give i order becouse i see that you sail filter,s olso for 150cc .! Its not my fault !! What i have to do . ? I dont need it.! Submitted on 27-3-2023 at 13:27
Reply Report abuse
we seem to find, only the kymco super 8, 50 and 150, Is the manual the same 125 the same as the 150 Submitted on 27-4-2022 at 23:16
Reply Report abuse

Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

Forumrules

To achieve meaningful questions, we apply the following rules:

First, read the manual;
Check if your question has been asked previously;
Try to ask your question as clearly as possible;
Did you already try to solve the problem? Please mention this;
Is your problem solved by a visitor then let him/her know in this forum;
To give a response to a question or answer, do not use this form but click on the button 'reply to this question';
Your question will be posted here and emailed to our subscribers. Therefore, avoid filling in personal details.

new questions and answers
new manuals

You will receive an email to register for one or both of the options.

Get your user manual by e-mail

Enter your email address to receive the manual of Kymco Super 8 - 150 in the language / languages: English as an attachment in your email.

The manual is 4,32 mb in size.

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.

Info

Kymco Super 8 - 150 Manual

Product: