657919
122
Zoom out
Zoom in
Previous page
1/152
Next page
21 TROUBLESHOOTING 120
Faults Possible cause Action
Engine stalls or is popping into the
carburetor
Lack of fuel
Turn handle
of the fuel tap to the ON posi-
tion. (Figure V00326-10 p. 17)
Refuel. ( p. 38)
Engine takes in bad air Check the intake flange and carburetor for
tightness.
The connector or ignition coil is loose
or oxidized
Clean the connector and treat it with contact
spray.
Engine overheats Too little coolant in cooling system Check the cooling system for leakage.
Check the coolant level. ( p. 100)
Too little air stream Switch off engine when stationary.
Radiator fins very dirty Clean the radiator fins.
Foam formation in cooling system Drain the coolant. ( p. 100)
Refill with coolant. ( p. 101)
Damaged cylinder head or cylinder
head gasket
Check the cylinder head and cylinder head gas-
ket.
Bent radiator hose Change the radiator hose.
Incorrect ignition point due to loose
stator
(All 125/150 models)
Adjust the ignition.
White smoke emission (steam in
exhaust gas)
Damaged cylinder head or cylinder
head gasket
Check the cylinder head and cylinder head gas-
ket.
Gear oil exits at the vent hose Too much gear oil added Check the gear oil level. ( p. 111)
Water in the gear oil Damaged shaft seal ring or water
pump
Check the shaft seal ring and water pump.
122


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for KTM 250 EXC - 2017 at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of KTM 250 EXC - 2017 in the language / languages: English as an attachment in your email.

The manual is 7,24 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info