Manual Chamberlain Power Drive (page 2 of 36) (English)

536963

Zoom out

Zoom in

1/36

Before you begin:

• Disable locks (contact your door manufacturer for

information on disabling your door locks.)

• Remove any ropes connected to garage door.

• Complete the following test to make sure your garage

door is balanced and is not sticking or binding:

1. Lift the door about halfway as shown. Release the

door. If balanced, it should stay in place, supported

entirely by its springs.

2. Raise and lower the door to see if there is any

binding or sticking.

If your door binds, sticks, or is out of balance, call a

trained door systems technician.

If you have a one-piece door, the installation of your

garage door opener will be different. Follow the assembly

instructions included in this manual then proceed to the

Installation Instructions For One-Piece Doors included with

the garage door opener.

To prevent damage to garage door and opener:

• ALWAYS disable locks BEFORE installing and operating

the opener.

• ONLY operate garage door opener at 120V, 60 Hz to avoid

malfunction and damage.

To prevent possible SERIOUS INJURY or DEATH:

• ALWAYS call a trained door systems technician if garage door

binds, sticks, or is out of balance. An unbalanced garage

door may not reverse when required.

• NEVER try to loosen, move or adjust garage door, door

springs, cables, pulleys, brackets or their hardware, ALL of

which are under EXTREME tension.

• Disable ALL locks and remove ALL ropes connected to

garage door BEFORE installing and operating garage door

opener to avoid entanglement.

WARNINGWARNING

CAUTION

WARNING

CAUTIONCAUTION

WARNING

Sectional Door

Preparing Your Garage Door . . . . . . . . . . . . . . . . . . . . . 2

Completed Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Tools Needed. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Opener Contents. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Assembly Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Installation Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-8

Installation

Installation safety instructions. . . . . . . . . . . . . . . . . . . . . . 9

Install the header bracket . . . . . . . . . . . . . . . . . . . . . . . . 10

Mount the header bracket . . . . . . . . . . . . . . . . . . . . . . . . 11

Position and hang motor unit . . . . . . . . . . . . . . . . . . . . . 12

Fasten the door bracket . . . . . . . . . . . . . . . . . . . . . . . . . 13

Attach door to trolley. . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Installing the door control . . . . . . . . . . . . . . . . . . . . . . . . 15

Installing the light bulb(s) . . . . . . . . . . . . . . . . . . . . . . . . 16

Electrical requirements . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Install the Protector System

. . . . . . . . . . . . . . . . . . . 17-18

Wire safety sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

Adjustment

Adjust the UP and DOWN travel limits . . . . . . . . . . . . . . 20

Adjust the forces . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Test the safety reversal system . . . . . . . . . . . . . . . . . . . 22

Test the Protector System

. . . . . . . . . . . . . . . . . . . . . . . 22

Operation

Important Safety Information . . . . . . . . . . . . . . . . . . . . . 23

Using your garage door opener . . . . . . . . . . . . . . . . . . . 23

Using the wall-mounted door control . . . . . . . . . . . . . . . 24

Care of your opener . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

To open the door manually . . . . . . . . . . . . . . . . . . . . . . . 24

Having a Problem? . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

Diagnostic Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

Programming

To add or reprogram an additional

hand-held remote control . . . . . . . . . . . . . . . . . . . . . . . . 27

To control the opener lights . . . . . . . . . . . . . . . . . . . . . . 27

Multi-function remotes. . . . . . . . . . . . . . . . . . . . . . . . . . . 27

To add, reprogram or

change a keyless entry PIN . . . . . . . . . . . . . . . . . . . . . . 28

To change an existing, known PIN . . . . . . . . . . . . . . . . . 28

To set a temporary PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 29

To erase all codes from motor unit memory . . . . . . . . . . 29

The remote control battery . . . . . . . . . . . . . . . . . . . . . . . 29

Repair Parts

Rail assembly parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Installation parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Motor unit assembly parts. . . . . . . . . . . . . . . . . . . . . . . . 31

Accessories. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Notes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33-34

Warranties . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

Repair Parts and Service . . . . . . . . . . . . . . . . . . . . . . . 36

TABLE OF CONTENTS

PREPARING YOUR GARAGE DOOR

One-Piece Door

See addendum

Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

Forumrules

To achieve meaningful questions, we apply the following rules:

First, read the manual;
Check if your question has been asked previously;
Try to ask your question as clearly as possible;
Did you already try to solve the problem? Please mention this;
Is your problem solved by a visitor then let him/her know in this forum;
To give a response to a question or answer, do not use this form but click on the button 'reply to this question';
Your question will be posted here and emailed to our subscribers. Therefore, avoid filling in personal details.

new questions and answers
new manuals

You will receive an email to register for one or both of the options.

Get your user manual by e-mail

Enter your email address to receive the manual of Chamberlain Power Drive in the language / languages: English as an attachment in your email.

The manual is 6,56 mb in size.

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.

Info

Chamberlain Power Drive Manual

Product: