803636

Babboe Max-E Manual

14
Zoom out
Zoom in
Previous page
1/35
Next page
ENGLISHDEUTSCHFRANÇAIS NEDERLANDS
2726
ERROR CODES
If the pedal assistance is not working properly, we recommend that you first check the various cable connections
and verify that the battery is sufficiently charged. As with any electronic system, a malfunction is possible. If this
is the case, please contact your Babboe dealer so that any repairs can be performed quickly.
The following table shows the error codes and their significance in the system. Potential causes and sources
serve as a guideline to determining where the error may occur.
ERROR
CODE
DESCRIPTION POTENTIAL CAUSES POSSIBLE
SOURCES
1Current Detection Error Internal short circuit, MOSFET failure,
current detection failure
Controller
2Battery
Communication Error
I2C bus failure, poor battery connection Battery, Controller
3Battery Cell Voltage
Error
Single cell voltage below 2.56V or above
5.12V
Battery, Controller
4Temperature Error Temperature of battery >50 or <-20C of
controller > 80 or < -20C
Battery, Controller
5Motor Stall Motor malfunction causing stalling Motor, Controller
6Battery Calibration
Error
Real voltage and read voltage difference
larger than 0.1V
Controller
7Pedal Error Signal Pedal error signal but controller OK Speed sensor
9Communication Error No communication between display and
controller
Display, Controller



BATTERY & CHARGING
Range
The range is the total distance you can travel with your electric Babboe cargo bike on a single trip without
recharging.
The minimal range of your electric Babboe cargo bike is typically > 25 km. However, the range is dependent
on many factors that can significantly shorten the range. Many of these factors can be overcome to positively
affect the range.
Influencing factors:
• The total weight (weight of the cargo bike + rider + load in the box)
• The resistance (wind, tire pressure*, speed, road conditions and differences in altitude)
• Your driving behaviour (shifting gears up and down in a timely manner and driving speed)
• The outdoor temperature
• Age of the battery (battery capacity decreases as the battery ages)
* Tires slowly deflate. Make sure you pump more air in the tires of your Babboe cargo bike every two weeks (3,5-4 bar).
IMPORTANT! PLEASE NOTE:
• To extend the range, the top speed of the assistance will slowly decrease as the battery drains.
• The performance of your battery will decrease at low temperatures. The range is optimal at a measured
temperature of approximately +/-25 °C. The guideline is that the capacity decreases by 1% with a temperature
drop of 1 °C.
Capacity of the battery
The battery of your Babboe cargo bike has a capacity of 11.4 Ah and a voltage of 32.85 volts. The battery provides 374 Wh.
IMPORTANT! PLEASE NOTE:
• In order to reach the maximum capacity of the battery, it must be fully charged/ discharged at least 10 times.
• Each year, the capacity may be reduced with up to 15%. The decrease is dependent on the usage and
charging cycles. It may happen that Babboe cargo bikes purchased at the same time have different ranges.
New batteries provide at least their minimum specified values, but there could be a slight variation.
It is possible that one of the Babboe cargo bikes performs above the specifications.
Inserting and disconnecting the battery
The pedal assistance must always be switched off when inserting or disconnecting the battery. If you want to
insert the battery in your Babboe cargo bike, slide the battery into the controller box (by the rear carrier). Then lock
the battery using the battery key, which is located on the left side of the controller box. To lock the battery, insert the
battery key into the lock and turn it counter clockwise.
To disconnect the battery, unlock the battery lock with the battery key clockwise. Then remove the battery from the
controller box by pulling the handle at the bottom of the battery.
… 14 …


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Babboe Max-E at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Babboe Max-E in the language / languages: English, German, Dutch, French as an attachment in your email.

The manual is 0.65 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info