810550
13
Zoom out
Zoom in
Previous page
1/28
Next page
| 13
CAST IRON FLOOR STANDING GAS BOILER
FAILURE STATES OF OPERATION
When these occur, the gas supply into the main burner and ignition burner is automatically closed:
ywhen the thermo-couple (ionisation electrode) is cooled because of: gas supply breakdown,
clogging by dirts, the flame extinguished by condensate, wrong setting of the thermo-couple
with reference to the ignition burner,
ywhen there is breakdown in the circuit of the boiler thermostat, the water in the boiler body gets
overheated.
The boiler operation cannot be started automatically in such cases. It is not possible to start the
boiler again without the professional service action to remove the problem.
What to do in the case of failure:
No. Failure
Possible cause
Removing Removed by
1. Water leakage from
unsealed areas
a1) released joint
a2) damaged sealing
element
a3) damaged cast iron
a1) tight the joint
a2) replace the element
a3) replace the cast iron
a1) service
a2) service
a3) service
2. Gas discharge from
unsealed areas
a) close the gas supply
b) find the place of leakage
and remove the failure
a) customer
b) service
3. The ignition burner is
not burning properly or
went off after start
a) low gas pressure a1) set up the flame by a
screw
a2) set up the gas pressure
a3) deaerate
a1) service
a2) service
a3) service
4. Boiler has a low output a) low gas pressure
b) unsuitable main jets
a) set up the gas pressure a) service
5. Ignition burner goes off
after igniting repeatedly
a) faulty emergency
thermostat
b) faulty thermocouple
c) faulty gas inlet valve
a) replace the thermostat
b) replace the
thermocouple
c) replace the valve
a) service
b) service
c) service
6. Hot water does not flow
into the heating system
a) same as by 5
b) boiler aerated, low water
pressure
c) faulty reversevalve or
pump
d) damaged thermostat
a) same as by 5
b) deaerate, fill in with
water
c) replace damaged parts
d) replace thermostat
a) same as by 5
b) customer
c) service
d) service
7. Main burners are not
ignited after switching
the thermostat
a) faulty gas valve
b) reset on the flue gas
thermostat activated
a) change the valve
b) check the flue, press
reset on the flue gas
thermostat
a) service
b) service
13


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for ATTACK KLV at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of ATTACK KLV in the language / languages: English as an attachment in your email.

The manual is 1.22 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info