524653

ACV HEATMASTER 30 N Manual

11
Zoom out
Zoom in
Previous page
1/26
Next page
ENFRRU PL DE IT ES NL
EN • 11
664Y5400•B
TECHNICAL CHARACTERISTICS
BOILER ROOM
- make sure that all air vents are unobstructed at all times.
- do not store any flammable products in the boiler room.
- do not store any corrosive products, paint, solvents, salts, chloride
products and other detergent products near the appliance.
- if you smell gas, do not switch on or off any lights, turn off the gas
meter, ventilate the rooms and contact your installer.
- The base on which the boiler rests must be made of non-combustible
materials.
CHIMNEY CONNECTION
- Chimney connection must comply with the applicable standards (NBN
D51-003 in Belgium), and take into account the local requirements
of the energy provider, the fire requirements and the regulation on
"noise pollution".
- The flue pipe size must not be smaller than the size of the boiler outlet
connection
B23 and B23P type chimney connection
The boiler is connected to the chimney by a metal pipe rising at an angle
from the boiler to the chimney. A flue disconnection piece is required.
It must be easily removable to give access to the flue pipes when
performing boiler maintenance.
Due to the high efficiency of our boilers, the flue gases exit at a low
temperature. Accordingly, there is a risk for the flue gases to condense,
which could damage the chimney and the boiler. Therefore, it is strongly
recommended to line the chimney.
`
Minimum supply of fresh air into
the boiler room
Fresh air supply
High Low
(B23 and B23P)
HeatMaster® 30N cm
2
≥ 150 ≥ 200
HeatMaster® 60N cm
2
≥ 150 ≥ 200
HeatMaster® 70 N cm
2
≥ 150 ≥ 200
HeatMaster® 100N cm
2
≥ 210 ≥ 320
Dimensions of a B23 type chimney
Height
5 m 10 m 15 m
HeatMaster® 30N Ø mm 150 150 150
HeatMaster® 60N Ø mm 189 159 150
HeatMaster® 70 N Ø mm 189 159 150
HeatMaster® 100N Ø mm 234 178 150
Note:
Given that regulations vary from one country to another,
the table above is given by way of indication only.
MAXIMUM OPERATING CONDITIONS
Maximum Service Pressure (DHW tank full of water)
- Primary circuit 3 bar
- DHW circuit 10 bar
Maximum Test Pressure (DHW tank full of water)
- Primary circuit 4.5 bar
- DHW circuit 13 bar
Maximum Operating Conditions
- Maximum temperature of primary fluid 90 °C
- Minimum temperature of primary fluid 60 °C
Water Quality
• Chlorides ≤ 150 mg/l (304)
• 6 ≤ pH ≤ 8
CHIMNEY CONNECTION CHARACTERISTICS
HEATMASTER® WITHOUT BURNER
HeatMaster®
30 N
HeatMaster®
60 N
HeatMaster®
70 N
HeatMaster®
100 N
Volume of the combustion chamber m
3
0.051 0.051 0.075 0.075
Mass flow rate of combustion products g/s 15.2 30.6 30.6 46.9
Max. pressure drop in flue pipe Pa 1 60 60 140
Flue pipe diameter mm 150 150 150 150
Net temperature °C 180 195 170 170
B23
✔ ✔ ✔ ✔
HEATMASTER® PROVIDED WITH AN ACV BG 2000S BURNER
HeatMaster®
30 N
+ BG 2000-S / 35
HeatMaster®
60 N
+ BG 2000-S / 60
HeatMaster®
70 N
+ BG 2000-S / 70
HeatMaster®
100 N
+ BG 2000-S / 100
Mass flow rate of combustion products g/sec. 16.0 32.1 32.1 51.4
Net temperature °C 163 186 172 165
B23
✔ ✔ ✔ ✔
B23P
✔ ✔ ✔ ✔
C13
✔ ✔ ✔ ✔
C33(x)
✔ ✔ ✔ ✔
C53(x)
✔ ✔ ✔ ✔
C63(x) - only in Germany and Luxemburg
✔
… 11 …


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for ACV HEATMASTER 30 N at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of ACV HEATMASTER 30 N in the language / languages: English as an attachment in your email.

The manual is 8,48 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of ACV HEATMASTER 30 N

ACV HEATMASTER 30 N User Manual - German - 26 pages

ACV HEATMASTER 30 N User Manual - Dutch - 20 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info